Figures
Abstract
Acetoin reductase/2,3-butanediol dehydrogenase (AR/BDH), which catalyzes the interconversion between acetoin and 2,3-butanediol, plays an important role in distribution of the products pools. This work characterized the Bacillus subtilis AR/BDH for the first time. The enzyme showed very different pH preferences of pH 6.5 for reduction and pH 8.5 for oxidation. Based on these above results, a two-stage pH control strategy was optimized for acetoin production, in which the pH was controlled at 6.5 for quickly converting glucose to acetoin and 2,3-butanediol, and then 8.0 for reversely transforming 2,3-butanediol to acetoin. By over-expression of AR/BDH in the wild-type B. subtilis JNA 3-10 and applying fed-batch fermentation based on the two-stage pH control strategy, acetoin yield of B. subtilis was improved to a new record of 73.6 g/l, with the productivity of 0.77 g/(l·h). The molar yield of acetoin was improved from 57.5% to 83.5% and the ratio of acetoin/2,3-butanediol was switched from 2.7∶1 to 18.0∶1.
Citation: Zhang X, Bao T, Rao Z, Yang T, Xu Z, Yang S, et al. (2014) Two-Stage pH Control Strategy Based on the pH Preference of Acetoin Reductase Regulates Acetoin and 2,3-Butanediol Distribution in Bacillus subtilis. PLoS ONE 9(3): e91187. https://doi.org/10.1371/journal.pone.0091187
Editor: Ivo G. Boneca, Institut Pasteur Paris, France
Received: October 23, 2013; Accepted: February 10, 2014; Published: March 7, 2014
Copyright: © 2014 Zhang et al. This is an open-access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.
Funding: This work was supported by the Program for New Century Excellent Talents in University (NCET-10-0459), the National Basic Research Program of China (973 Program) (2012CB725202), the National Natural Science Foundation of China (21276110), the Research Project of Chinese Ministry of Education (No.113033A), the Fundamental Research Funds for the Central Universities (JUSRP51306A and JUSRP21121), the 111 Project (111-2-06) and a Project Funded by the Priority Academic Program Development of Jiangsu Higher Education Institution. The funders had no role in study design, data collection and analysis, decision to publish, or preparation of the manuscript.
Competing interests: The authors have declared that no competing interests exist.
Introduction
Acetoin, naturally in fruits, corn, meet and some fermented food, is a famous spice that can be used to add flavor to food. It can also be used in cosmetics and chemical synthesis. Fermentation of acetoin by microorganisms is favorable since the process can use cheap substrate and has less environmental stresses. The vital physiological significance of acetoin to microorganisms is mainly in avoiding acidification, participating in the regulation of NADH/NAD+ ratio and storing carbon [1]. With the increasing demand of food flavor, nature acetoin produced by microbial fermentation is popular.
Many species such as Saccharomyces cerevisiae [2], Leuconostoc mesenteroides [3], Enterobacter aerogenes [4], Bacillus subtilis [5], Serratia marcescens [6], Lactococcus lactis [7], Klebsiella oxytoca [8] and Paenibacillus polymyxa [9] can be used to produce acetoin. However, in many cases, acetoin is only a byproduct of 2,3-butanediol during the fermentation, which is also an very important chemical [10]. Among the strains mentioned above, Bacillus species, on the Food and Drug Administration's GRAS (generally regarded as safe) list, have been developed and engineered as industrial producers of nucleotides, the vitamin riboflavin, the flavor agent ribose, and the supplement poly-gamma-glutamic acid [11]. With the characterization of B. subtilis genome, the species is poised to become a preferred host for the production of many new and improved products [12]. Our lab isolated a B. subtilis strain, which produced 42.2 g/l acetoin and 15.8 g/l 2,3-butanediol in about 132 h. The strain could reversely transform 2,3-butanediol to acetoin in the decline phase of fermentation by the enzyme acetoin reductase/2,3-butanediol dehydrogenase (AR/BDH EC 1.1.1.4) [5] (Figure 1).
ALS: α-acetolactic acid synthase; ALDC: α-acetolactic acid decarboxylase; AR/BDH: acetoin reductase/2,3-butanediol dehydrogenase.
AR/BDH, also named diacetyl reductase, catalyses both the reversible oxidation of 2,3-butanediol to acetoin and the practically irreversible reduction of diacetyl to acetoin [13], [14]. The enzyme plays an important role in distribution of acetoin and 2,3-butanediol proportions as well as NADH/NAD+ pools. It has been purified and characterized from several microorganisms. AR/BDH has very strict cofactor specificity and can only utilize NADH for reduction and NAD+ for oxidation. A very special property of AR/BDH has been reported that it has different optimum pH-values for oxidation and reduction, respectively. Table 1 shows the specific optimum pH values of AR/BDH from Bacillus polymyxa, Serratia marcescens, Gluconobacter oxydans [15], Lactococcus lactis [16], Saccharomyces cerevisiae [17]-[19], Pyrococcus furiosus [20] and Rhodococcus erythropolis WZ010 [21]. The results indicate that the enzyme AR/BDH preferentially catalyzes the reduction/oxidation reaction in the acidic/alkaline condition.
Recently, for improving acetoin production, efforts have been focused on screening new bacterial strains [8], [22]-[24] and optimizing the fermentation mediums [25], [26]. New findings have also proved that the fermentation duration can be shortened effectively and acetoin production can be improved by changing the agitation speed to control the dissolved oxygen levels [23], [27]. However, there was still considerable amount of byproduct 2,3-butanediol through these above efforts. The similar problem existed in 2,3-butanediol producers that acetoin was a major byproduct in the fermentation. These byproducts produced by the catalysis of AR/BDH caused the loss of substrate and energy. Science AR/BDH plays such a critical role in distribution of acetoin and 2,3-butanediol proportions, the reversal reaction by this enzyme restrains the improvement of acetoin production. Therefore, besides screening of new bacterial strains, optimizing the culture mediums and controlling the dissolved oxygen levels, the conditions for AR/BDH reaction during fermentation should have the priority to be studied. The B. subtilis AR/BDH, encoded by the bdhA gene [28], had been over-expressed in Escherichia coli BL21 [29]. But the enzyme has never been purified and characterized, which limits the optimum use of B. subtilis for acetoin or 2,3-butanediol production.
In this work, the AR/BDH from B. subtilis JNA 3–10 was cloned and overexpressed, and its properties were studied for the first time. Based on pH preferences of AR/BDH, the two-stage pH control strategy was proposed to redistribute acetoin and 2,3-butanediol proportions. With the optimum pH control strategy for acetoin production, the recombinant B. subtilis overexpressing AR/BDH was used to yield abundant amount of acetoin and decrease the yield of byproduct 2,3-butanediol.
Materials and Methods
Strains, plasmids and primers
The strains, plasmids and primers used in this study were listed in Table 2.
Preparation of crude enzyme and AR/BDH purification
The recombinant B. subtilis was cultured in Luria-Bertain (LB) medium at 37°C on a rotary shaker at 160 rpm. After cultured for 24 h, cells were collected by centrifugation at 8000 rpm for 30 min at 4°C. The cell pellets were suspended and washed with 0.1 M potassium phosphate buffer (pH 7.0) for there times. For preparation of crude AR/BDH, the cells were resuspended in 0.1 M potassium phosphate buffer containing 0.1 mM β-Mercaptoethanol and 2 µg/ml PMSF, pH 6.5. Crude enzyme was prepared by sonication after treated with 1 mg/ml lysozyme for 60 min at 4°C. The homogenate was centrifuged at 15,000 rpm for 60 min at 4°C. The activity of AR/BDH was detected as described previously [28].
The recombinant AR/BDH was expressed as a His6-tagged protein in B. subtilis JNA 3–10. The recombinant protein was purified by affinity chromatography on a Ni-NTA agarose prepacked column HisTrap HP (GE Healthcare, Uppsala, Sweden). The pooled fractions were then loaded on a Superdex™ 200 (10/300 GL) equilibrated with the buffer (20 mM Tris-HCl and 150 mM NaCl, pH 8.0) using an ÄKTA Protein Purifier system (Pharmacia, Uppsala, Sweden). The enzyme was assayed by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) according to Laemmli method [30]. The molecular weight of protein was determined by comparing the relative mobility of perfect protein Marker 14.4–116 kDa (Thermo, USA). The protein concentration was determined by Bradford method [31] using BSA as the standard protein.
Effect of pH and temperature on enzyme activity and stability
The following buffer systems were used to investigate the pH dependence of AR/BDH: 50 mM sodium acetate buffer (pH 4.5∼6.0), 50 mM phosphate buffered saline buffer (PBS buffer, pH 6.0∼8.0) and 50 mM glycine-NaOH buffer (pH 8.0∼10.5). The spontaneous oxidation of NADH in buffers of low pH was corrected when detecting the effect of pH on enzyme activity. The activity of AR/BDH was assayed at different temperatures from 25°C to 60°C with a gradient of 5°C. The enzyme stability was investigated using the standard AR/BDH assay after it had been incubated for 2 h under different conditions.
Effect of chemical inhibitors and stimulators on enzyme activity
The influence of a variety of mental ions and EDTA on enzyme activity was determined. The reaction mixture containing 100 ng enzyme in 50 mM PBS buffer (pH 6.5 for reduction activity and pH 8.5 for oxidation activity) were incubated in the appropriate chemical for 20 min at 25°C. After preincubation, NADH/NAD+ (final concentration 0.2 mM/1.2 mM) was added and AR/BDH activity was measured with 10 mM acetoin/2,3-butanediol as substrate. The following chemicals were assayed at a final concentration of both 1 mM and 3 mM: NaCl, KCl, MgSO4, MnSO4, ZnCl2, CaCl2, CuSO4 and EDTA.
Substrate specificity and kinetics properties
The oxidation/reduction of NADH/NAD+ and NADPH/NADP+ with the consumption of acetoin/2,3-butanediol were measured under standard assay conditions described for AR/BDH, to test if these pyridine nucleotides could act as alternative electron donors/accepters. The Km and Vmax values were determined from Lineweaver-Burk plots of the data.
Culture conditions
B. subtilis and Escherichia coli were cultured in Luria-Bertani (LB) medium at 37°C on a rotary shaker at 160 rpm. When necessary, the LB medium was supplemented with 100 µg/ml ampicillin or 50 µg/ml kanamycin. For acetoin fermentation, the cells were inoculated into 10 ml LB medium, cultivated for 7–9 h, and then 1 ml of the culture was transferred into 50 ml seed medium (LB with 40 g/L glucose) for preparing the seed culture. After 10 h, 2.5 ml of the seed culture (OD600 = 5.0–6.0) was inoculated into 50 ml of fermentation medium (glucose 100 g/l, beef extract 5 g/l, corn steep liquor 20 g/l, and urea 2 g/l). When fermentation carried out in a 5-L fermentor (Biotech Co., Shanghai, China), the agitation speed was set at 300 rpm.
Analytical methods
Residual glucose was detected using a SBA-40C biological sensing analyzer (SBA, China). Acetoin and 2,3-butanediol were detected by gas chromatography (Jie Dao GC1600, China, FID detector, N2 flow rate of 50 ml/min, detector temperature of 250°C, and a column temperature of 160°C). Biomass was measured spectrophotometrically at 600 nm (UNICO UV-2000, USA). All assays were performed in duplicate or triplicate.
Results and Discussion
Expression and purification of AR/BDH
Plasmid pMA5-bdhA was constructed and transformed into B. subtilis JNA 3–10, resulting in BSA strain. After cultured for 24 h, the cells of BSA strain were collected for preparation of crude AR/BDH. The purification of the B. subtilis AR/BDH relies on affinity binding of enzyme with His-tag by Ni2+. The apparent subunit molecular mass of the AR/BDH was about 38-39 kDa as determined by SDS-PAGE (Figure 2). The protein was purified about 18-fold and has a specific activity of 140.9 mU/mg (Figure 3).
Lanes 1: BSA; 2: B. subtilis JNA 3–10; M: molecular mass standards.
Lanes 1, 2: AR/BDH; M: molecular mass standards.
BSATemperature and pH dependence of B. subtilis AR/BDH
The optimum temperature for AR/BDH activity was about 55°C/50°C (Figure 4). However, the enzyme showed very different optimum pH dependences on the reduction and oxidation reactions, which were pH 6.5 and pH 8.5 respectively (Figure 5). The enzyme was very unstable when stored above 20°C. After incubated at 0°C for 2 hours, the enzyme maintained only 80% activity.
Reduction (AR); Oxidation (BDH).
Reduction (AR); Oxidation (BDH).
strain Chemical inhibitors and stimulators
Of all the chemicals listed in Table 3, we investigated that 3 mM Mn2+ greatly stimulated the activity of BDH, while Zn2+ and Cn2+ had inhibitive effects on both AR and BDH activities. Ca2+ showed a weak activation effect on BDH activity but no effect on AR activity. The other metals and EDTA did not enhance or inhibit AR and BDH activities obviously (within the range of ± 15%).
Substrate specificity and kinetics properties
Under standard assay condition described for AR/BDH, the NADH/NAD+ was directly oxidized/reduced while NADPH/NADP+ was not detectably oxidized/reduced by the enzyme. The Km and Vmax values for NADH/NAD+ and acetoin/2,3-butanediol were given in Table 4. The catalytic efficiency constant, kcat/Km, were greater for the reduction of acetoin than for the oxidation of 2,3-butanediol, indicating the enzyme could preferentially function as a reductase rather than as a dehydrogenase.
Effect of initial pH on acetoin fermentation
In previous shake flask fermentation, the fermentation medium was not adjusted with nature pH (after autoclaved sterilization, the medium pH was about 6.2∼6.4). B. subtilis JNA 3–10 could completely consume 100 g/l glucose in about 72 h accompanied by rapid accumulation of 2,3-butanediol, then part of 2,3-butanediol was reversely transformed into acetoin. At about 120 h, 25.2 g/l acetoin and 19.8 g/l 2,3-butanediol could be obtained. Since the optimum pH of AR and BDH have very different preferences, this work studied the effect of the initial pH (5.0, 6.0, 7.0 and 8.0) of the medium on B. subtilis JNA 3–10 fermentation in shake flask (Figure 6). The results indicated that fermentation pH played a vital role in acetoin/2,3-butanediol proportion.
Cell growth and glucose consumption rate.
The results showed that glucose consumption rate was coupled with cell growth. When the initial fermentation pH was 5.0, cell growth was inhibited greatly and was accompanied by very slowly glucose consumption rate (Figure 6 A). The highest glucose consumption rate was observed when initial fermentation pH was 6.0 (Figure 6 B), about 100 g/l glucose was consumed within 72 h, suggesting faintly acid environment was favorable for B. subtilis growth. However, when the initial fermentation pH was equal or higher than 9.0, the cells can not growth (data was not shown).
Acetoin and 2,3-butanediol production.
When the initial fermentation pH was 6.0, with the highest glucose consumption rate, the acetoin production was the lowest compared whit that of pH 7.0 (Figure 6 C) and pH 8.0 (Figure 6 D). When the initial fermentation pH was raised artificially, the efficiency of 2,3-butanediol production was decreased, because the tendency of the reversible reaction between acetoin and 2,3-butanediol was moving in the direction of BDH.
At the end of fermentation, the culture pH reached to about the same level, suggesting B. subtilis strain can adjust its own acid-base equilibrium by fermentation. Therefore, in decline phase of fermentation, there were little differences in the transformation rates from 2,3-butanediol to acetoin. We also observed that the reversal of AR/BDH reaction only occurred when fermentation just entered the late stationary phase or the decline phase. The results strongly recommended that controlling of the pH that favorable for BDH activity while fermentation entered the late stationary phase could further increase acetoin production.
Two-stage pH control strategies in 5-L fermentor
The two-stage pH control strategy was proposed based on comprehensive consideration of the cell growth, glucose consumption rate and AR/BDH activity. In a 5-L fermentor, the fermentation pH was first controlled around 6.0 (5.5, 6.0 and 6.5), which was supposed to quickly consume glucose (Figure 7). The results demonstrated that 150 g/l glucose was totally consumed in 60 h at pH 6.5, and the biomass was the highest in this condition. Once the cells fermented into the late stationary phase, 2,3-butanediol was reversely transformed into acetoin. Then we proposed to speed the reverse transformation process at about 48 h by switching the fermentation pH from 6.5 to around 8.0 (7.5, 8.0 and 8.5) (Figure 8). The results showed that pH 8.0 was favorable for quickly transforming 2,3-butanediol to acetoin in the fermentation. Thought the optimum pH for BDH oxidation was 8.5, the biomass decreased greatly and the enzyme inactivated quickly at that pH. Thus, the optimum strategy for the two-stage pH control fermentation was proposed at pH 6.5 in the first 48 h and pH 8.0 at the last 48 h (Figure 8 B). Using this strategy, 150 g/l glucose was converted into 56.8 g/l acetoin and 6.1 g/l 2,3-butanediol. Acetoin productivity was improved to 0.59 g/(l·h), about 84% higher than described previously (produced 42.2 g/l acetoin in 132 h, with acetoin molar yield of 57.5% and productivity of 0.32 g/(l·h)) [5].
The fermentation was under different pH and was terminated on the depletion of glucose. A (pH 5.5); B (pH 6.0); C (pH 6.5).
A (pH 6.5 for the first 48 h and pH 7.5 for the last 48 h); B (pH 6.5 for the first 48 h and pH 8.0 for the last 48 h); C (pH 6.5 for the first 48 h and pH 8.5 for the last 48 h).
B Highly improved acetoin production by over-expression of the AR/BDH
To investigate the significant role of AR/BDH in redistribution of the metabolic flux between acetoin and 2,3-butanediol. The recombinant strain BSA was then fermented based on the optimum two-stage pH control strategy. In the two-stage pH control fermentation described above, glucose was totally consumed in about 60 h. Thus, fed-batch fermentation was proposed during the second stage of fermentation, in which the pH was controlled at 8.0 (Figure 9).
A (strain JNA 3–10); B(strain BSA).
By over-expression of AR/BDH, the transformation rate between acetoin and 2,3-butanediol was obviously increased (Figure 9 B) compared to JNA 3-10 (Figure 9 A). In the first stage of fermentation, acetoin was immediately transformed to 2,3-butanediol after it was synthesized from α-acetolactic acid. As soon as the fermentation pH was switched to 8.0, 2,3-butanediol was reversely transformed to acetoin. Almost all of the byproduct 2,3-butanediol was transformed to acetoin by the recombinant strain (4.1 g/l left) compare to JNA 3-10 (7.1 g/l left). While the yield of 2,3-butanediol was decreased to a low level, it can not be reversely transformed to acetoin, indicating other restrictive factors such as NADH/NAD+ [32] or dissolved oxygen levels [23], [27] may restrain the reversible reaction. In the second stage of fermentation, acetoin was quickly accumulated not only because of the reversible enzymatic reaction but also the conversion from glucose. The over-expression of AR/BDH enhanced the consumption rate of glucose, and JNA 3–10 and BSA consumed about 163 g/l and 180 g/l glucose, respectively, which corresponding to the total acetoin and 2,3-butanediol production of 70.3 g/l and 77.7 g/l. By applying over-expression of AR/BDH and fed-batch fermentation based on the two-stage pH control strategy, acetoin production was improved to 73.6 g/l. By consumption of about 180 g/l glucose, acetoin molar yield was 83.5%, with a productivity of 0.77 g/(l·h). To our knowledge, it is the highest record of acetoin production in the GRAS B. subtilis.
Conclusions
B. subtilis AR/BDH was characterized in this work for the first time, and the recombinant enzyme was found to have optimum pH values of 6.5 for reduction and 8.5 for oxidation. A two-stage pH control strategy was proposed and optimized for acetoin production based on the pH preference of AR/BDH, in which the fermentation pH was controlled at 6.5 for the first 48 h and 8.0 for the last 48 h, respectively. By over-expression of AR/BDH and fed-batch fermentation based on the pH control strategy, acetoin yield was further improved to 73.6 g/l, which is the highest record of GRAS B. subtilis.
Author Contributions
Conceived and designed the experiments: XZ ZR HL TB. Performed the experiments: XZ TB TY. Analyzed the data: XZ TB ZX SY. Contributed reagents/materials/analysis tools: ZR HL. Wrote the paper: XZ TB ZR.
References
- 1. Xiao ZJ, Xu P (2007) Acetoin metabolism in bacteria. Crit Rev Microbiol 33: 127–140.
- 2. Romano P, Suzzi G (1993) Acetoin production in Saccharomyces cerevisiae wine yeasts. FEMS Microbiol Lett 108: 23–26.
- 3. Schmitt P, Vasseur C, Phalip V, Huang DQ, Divies C, et al. (1997) Diacetyl and acetoin production from the co-metabolism of citrate and xylose by Leuconostoc mesenteroides subsp. mesenteroides. Appl Microbiol Biotechnol 47: 715–718.
- 4. Geckil H, Barak Z, Chipman DM, Erenler SO, Webster DA, et al. (2004) Enhanced production of acetoin and butanediol in recombinant Enterobacter aerogenes carrying Vitreoscilla hemoglobin gene. Bioprocess Biosyst Eng 26: 325–330.
- 5. Zhang X, Yang TW, Lin Q, Xu MJ, Xia HF, et al. (2011) Isolation and identification of an acetoin high production bacterium that can reverse transform 2,3-butanediol to acetoin at the decline phase of fermentation. World J Microbiol Biotechnol 27: 2785–2790.
- 6. Sun J, Zhang L, Rao B, Shen Y, Wei D (2012) Enhanced acetoin production by Serratia marcescens H32 with expression of a water-forming NADH oxidase. Bioresour Technol 119: 94–98.
- 7. Passerini D, Laroute V, Coddeville M, Le Bourgeois P, Loubiere P, et al. (2013) New insights into Lactococcus lactis diacetyl- and acetoin-producing strains isolated from diverse origins. Int J Food Microbiol 160: 329–336.
- 8. Cho S, Kim KD, Ahn JH, Lee J, Kim SW, et al. (2013) Selective Production of 2,3-Butanediol and Acetoin by a Newly Isolated Bacterium Klebsiella oxytoca M1. Appl Biochem Biotechnol 170: 1922–1933.
- 9. Gao J, Xu YY, Li FW, Ding G (2013) Production of S-acetoin from diacetyl by Escherichia coli transformant cells that express the diacetyl reductase gene of Paenibacillus polymyxa ZJ-9. Lett Appl Microbiol 57: 274–281.
- 10. Ji XJ, Huang H, Ouyang PK (2011) Microbial 2,3-butanediol production: A state-of-the-art review. Biotechnol Adv 29: 351–364.
- 11. Schallmey M, Singh A, Ward OP (2004) Developments in the use of Bacillus species for industrial production. Can J Microbiol 50: 1–17.
- 12. Kunst F, Ogasawara N, Moszer I, Albertini AM, Alloni G, et al. (1997) The complete genome sequence of the gram-positive bacterium Bacillus subtilis. Nature 390: 249–256.
- 13. Kavadze AV, Rodopulo AK, Shaposhnikov GL (1979) Isolation, purification, and study of certain properties of diacetyl(acetoin) reductase in the yeast Saccharomyces vini. Biol Bull Acad Sci USSR 6: 356–361.
- 14. Siemerink MA, Kuit W, Lopez Contreras AM, Eggink G, van der Oost J, et al. (2011) D-2,3-butanediol production due to heterologous expression of an acetoin reductase in Clostridium acetobutylicum. Appl Environ Microbiol 77: 2582–2588.
- 15. Hohn-Bentz H, Radler F (1978) Bacterial 2,3-butanediol dehydrogenases. Arch Microbiol 116: 197–203.
- 16. Crow VL (1990) Properties of 2,3-butanediol dehydrogenases from Lactococcus lactis subsp. lactis in relation to citrate fermentation. Appl Environ Microbiol 56: 1656–1665.
- 17. Heidlas J, Tressl R (1990) Purification and characterization of a (R)-2,3-butanediol dehydrogenase from Saccharomyces cerevisiae. Arch Microbiol 154: 267–273.
- 18. Gonzalez E, Fernandez MR, Larroy C, Sola L, Pericas MA, et al. (2000) Characterization of a (2R,3R)-2,3-butanediol dehydrogenase as the Saccharomyces cerevisiae YAL060W gene product - Disruption and induction of the gene. J Biol Chem 275: 35876–35885.
- 19. Ehsani M, Fernandez MR, Biosca JA, Dequin S (2009) Reversal of coenzyme specificity of 2,3-butanediol dehydrogenase from Saccharomyces cerevisae and in vivo functional analysis. Biotechnol Bioeng 104: 381–389.
- 20. Machielsen R, Uria AR, Kengen SW, van der Oost J (2006) Production and characterization of a thermostable alcohol dehydrogenase that belongs to the aldo-keto reductase superfamily. Appl Environ Microbiol 72: 233–238.
- 21.
Wang Z, Song Q, Yu M, Wang Y, Xiong B, et al. (2013) Characterization of a stereospecific acetoin(diacetyl) reductase from Rhodococcus erythropolis WZ010 and its application for the synthesis of (2S,3S)-2,3-butanediol. Appl Microbiol Biotechnol DOI10.1007/s00253-013-4870-5.
- 22. Xiao ZJ, Wang XM, Huang YL, Huo FF, Zhu XK, et al. (2012) Thermophilic fermentation of acetoin and 2,3-butanediol by a novel Geobacillus strain. Biotechnol Biofuels 5: 88–97.
- 23. Sun J, Zhang L, Rao B, Han Y, Chu J, et al. (2012) Enhanced acetoin production by Serratia marcescens H32 using statistical optimization and a two-stage agitation speed control strategy. Biotechnol Bioproc E 17: 598–605.
- 24. Passerini D, Laroute V, Coddeville M, Le Bourgeois P, Loubiere P, et al. (2013) New insights into Lactococcus lactis diacetyl- and acetoin-producing strains isolated from diverse origins. Int J Food Microbiol 160: 329–336.
- 25. Xiao ZJ, Liu PH, Qin JY, Xu P (2007) Statistical optimization of medium components for enhanced acetoin production from molasses and soybean meal hydrolysate. Appl Microbiol Biotechnol 74: 61–68.
- 26. Cogan TM, O'Dowd M, Mellerick D (1981) Effects of pH and sugar on acetoin production from citrate by Leuconostoc lactis. Appl Environ Microbiol 41: 1–8.
- 27. Zhang YJ, Li SB, Liu LM, Wu J (2013) Acetoin production enhanced by manipulating carbon flux in a newly isolated Bacillus amyloliquefaciens. Bioresour Technol 130: 256–260.
- 28. Nicholson WL (2008) The Bacillus subtilis ydjL (bdhA) gene encodes acetoin reductase/2,3-butanediol dehydrogenase. Appl Environ Microbiol 74: 6832–6838.
- 29. Xiao Z, Lv C, Gao C, Qin J, Ma C, et al. (2010) A novel whole-cell biocatalyst with NAD+ regeneration for production of chiral chemicals. PLoS One 5: e8860.
- 30. Laemmli UK (1970) Cleavage of structural proteins during the assembly of the head of bacteriophage T4. Nature 227: 680–685.
- 31. Bradford MM (1976) A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Anal Biochem 72: 248–254.
- 32.
Zhang X, Zhang R, Bao T, Yang T, Xu M, et al. (2013) Moderate expression of the transcriptional regulator ALsR enhances acetoin production by Bacillus subtilis. J Ind Microbiol Biotechnol.